Draw-tite 24775 SPORTFRAME HITCH Manuel d'utilisateur télécharger pdf (Page 1)

Installation Instructions

Mazda 6 - Sedan & 5-Door (does not fit wagons)

Ford Fusion, Mercury Milan, Lincoln Zephyr,

Lincoln MKZ

Part Numbers:

77152

24775

60846

Hitch Shown In Proper Position

Wiring Access Location: PC3, PC4

Equipment Required: Pull Wire (Provided)

Wrenches: 12mm, 13mm, 3/4

Drill Bits: ½”

1. Lower muffler by removing (3) rubber isolator hangers, (2) located near the end of the muffler and the remaining hanger forward

of the rear axle. Remove (2) rubber plugs from the trunk pan (if present).

2. Remove 8mm bolt, located on the inside of the frame rail on the bulkhead, both sides of vehicle. Discard bolts.

3. Slide hitch above tailpipes with inner bumper straps sliding under fascia (Note: Care must be taken when sliding inner bumper

straps under fascia to prevent scratching). Install 8mm bolts (Item

7) loosely thru upright brackets.

4. If vehicle bumper has a slots which line up with hole in inner bumper strap, proceed to step 5. If no slots exist, use hitch inner

bumper straps as a template to drill (2) ½” holes in vehicle bumper.

5. Install carriage bolt and block (Item

3) thru inner bumper structure with pull wire, carefully pulling fastener thru existing

slot/drilled hole in bumper and hitch. Install conical toothed washer and nut.

Tighten all ½-13 GR5 fasteners to 75 lb.-ft. (102 N*M)

Tighten all 8mm fasteners to 25 lb.-ft. (34 N*M)

6. Install hex bolt and block (Item

4) thru holes in trunk pan, if present. If holes are not present, remove spare tire and use hitch

as a template to drill (2) ½” holes in trunk pan. Install fasteners as shown.

Tighten all ½-13 GR5 fasteners to 75 lb.-ft. (102 N*M)

7. Seal holes in trunk pan to prevent intrusion of exhaust fumes or water.

8. Reinstall muffler, (3) places.

9. Reinstall spare tire in trunk.

Rev. D10-22-0724775NSheet 1 of 3

z 2006, 2007 Cequent Towing Products

Bolt M8 x 1.25 x 35mm CL9.8Qty. (2)

Block ¼ x 1 x 2Qty. (2)

Block 3/16 x 1-1/2 x 2 Qty. (2)

Nut ½-13 Qty. (4)

Carriage Bolt ½-13 Gr. 5Qty. (2)

Conical Toothed Washer 1/2”Qty. (4)

Hex Bolt ½-13 x 1-1/2” Gr. 5Qty. (2)

Note: check hitch frequently, making sure all fasteners and ball are properly tightened. If hitch is removed, plug all holes in trunk pan or other body panels to

prevent entry of water and exhaust fumes. A hitch or ball which has been damaged should be removed and replaced. Observe safety precautions when working

beneath a vehicle and wear eye protection. Do not cut access or attachment holes with a torch.

This product complies with safety specifications and requirements for connecting devices and towing systems of the state of New York, V.E.S.C. Regulation V-5

and SAE J684.

2000 LB (908 Kg) Max Gross Trailer Weight

200 LB (90.8Kg) Max Tongue Weight

Do Not Exceed Lower of Towing Vehicle

Manufacturer’s Rating or

Drawbar must be used in the

Rise

position only.

Drawbar Kit:

3592

Fastener Kit: 24775F

Form F206 Rev A 5605

Pull Wire

Trunk Pan – Spare

Tire Well

Inner Bumper Structure

Trunk Pan/Spare

Tire Well

Inner Bumper Structure

Fascia

Fasteners Typical

Both Sides of Vehicle

Inner Bumper

Strap

Bumper

Existing Holes or

Holes to be Drilled

Note: Remove Spare Tire

Before Drilling

Optional Drawbar (Sold Seperately)

For MAZDA 6 ONLY

3594

Drawbar must be used in the RISE

Position only.

1 2 3

Résumé du contenu

Page 1 - Installation Instructions

Installation InstructionsMazda 6 - Sedan & 5-Door (does not fit wagons)Ford Fusion, Mercury Milan, Lincoln Zephyr, Lincoln MKZPart Numbers:7715224

Page 2 - Instructions d’installation

Instructions d’installationMazda 6 - Sedan et 5 portes (sauf familiales)Ford Fusion, Mercury Milan, Lincoln Zephyr, Lincoln MKZNuméros de pièces :7715

Page 3 - Instrucciones de instalación

Instrucciones de instalaciónMazda 6 - Sedan y 5 puertas (no se ajusta a los vehículos tipo wagon)Ford Fusion, Mercury Milan, Lincoln Zephyr, Lincoln M

Commentaires sur ces manuels

Pas de commentaire

Draw-tite 24775 SPORTFRAME HITCH Manuel d'utilisateur Page 1

Naviguer en ligne ou télécharger Manuel d'utilisateur pour Pour la voiture Draw-tite 24775 SPORTFRAME HITCH. Draw-Tite 24775 SPORTFRAME HITCH User Manual Manuel d'utilisatio

Résumé du contenu

Commentaires sur ces manuels

Draw-tite 24775 SPORTFRAME HITCH Manuel d'utilisateur Page 1

Naviguer en ligne ou télécharger Manuel d'utilisateur pour Pour la voiture Draw-tite 24775 SPORTFRAME HITCH. Draw-Tite 24775 SPORTFRAME HITCH User Manual Manuel d'utilisatio

Résumé du contenu

Commentaires sur ces manuels

Produits connexes et manuels pour Pour la voiture Draw-tite 24775 SPORTFRAME HITCH